Comparative sensitivity study of primary cells, vero, OA3.Ts and ESH-L cell lines to lumpy skin disease, sheeppox, and goatpox viruses detection and growth.

Lumpy skin disease virus (LSDV), sheeppox virus (SPPV) and goatpox (GTPV) virus have been usually grown on primary cells for diagnosis, production and titration purposes. The use of primary cells present several inconvenient, heavy preparation, heterogeneous cell population, non-reproducible viral titration and presence of potential endogenous contaminants. Therefore investigating sensitivity of candidate continuous cell lines is needed. In this study, we compared the above Capripox viruses (CaPVs) sensitivity of primary cells of four origin (heart, skin, testis and kidney), with three cell lines (Vero, OA3.Ts and ESH-L). We tested sensitivity for virus isolation, replication cycle and titration, revealed by cytopathic effect (CPE), immunoenzymatic staining and immunofluorescence. Our results show that ESH-L cells and primary fetal heart cells present the highest sensitivity for CaPVs growth and detection. Vero cells can replicate those viruses but without showing any CPE while the titer obtained on OA3.Ts is lower than primary and ESH-L cells. ESH-L cells are an effective alternative to primary cells use for growing Capripoxviruses and their diagnosis.

Production of small ruminant morbillivirus, rift valley fever virus and lumpy skin disease virus in CelCradle™ -500A bioreactors.

BACKGROUND: Animal vaccination is an important way to stop the spread of diseases causing immense damage to livestock and economic losses and the potential transmission to humans. Therefore effective method for vaccine production using simple and inexpensive bioprocessing solutions is very essential. Conventional culture systems currently in use, tend to be uneconomic in terms of labor and time involved. Besides, they offer a limited surface area for growth of cells. In this study, the CelCradle™-500A was evaluated as an alternative to replace conventional culture systems in use such as Cell factories for the production of viral vaccines against small ruminant morbillivirus (PPR), rift valley fever virus (RVF) and lumpy skin disease virus (LSD). RESULTS: Two types of cells Vero and primary Lamb Testis cells were used to produce these viruses. The study was done in 2 phases as a) optimization of cell growth and b) virus cultivation. Vero cells could be grown to significantly higher cell densities of 3.04 × 109 using the CelCradle™-500A with a shorter doubling time as compared to 9.45 × 108 cells in Cell factories. This represents a 19 fold increase in cell numbers as compared to seeding vs only 3.7 fold in Cell factories. LT cells achieved modestly higher cell densities of 6.7 × 108 as compared to 6.3 × 108 in Cell factories. The fold change in densities for these cells was 3 fold in the CelCradle™-500A vs 2.5 fold in Cell factories. The titers in the conventional system and the bioreactor were not significantly different. However, the Cell-specific virus yield for rift valley fever virus and lumpy skin disease virus are higher (25 virions/cell for rift valley fever virus, and 21.9 virions/cell for lumpy skin disease virus versus 19.9 virions/cell for rift valley fever virus and 10 virions/cell for lumpy skin disease virus). CONCLUSIONS: This work represents a novel study for primary lamb testis cell culture in CellCradle™-500A bioreactors. In addition, on account of the high cell densities obtained and the linear scalability the titers could be further optimized using other culture process such us perfusion.